Latest topics
» F B Spares
Yesterday at 9:01 pm by bill2b

» Cruiser 89 air filter for Viliers 4T engine
Yesterday at 4:39 pm by piston 197

» Fulmar Speedo on ebay
Yesterday at 12:59 pm by fulmar88

» What's this from
Yesterday at 10:09 am by john87

» tank badge fixing screws
Yesterday at 1:39 am by intrudin

» Plover with Engine Number 12T 5090
Mon Nov 20, 2017 8:49 pm by Farley

» wheel nut
Mon Nov 20, 2017 11:30 am by alan67

» Fuel Tank cap
Sun Nov 19, 2017 9:00 pm by bill2b

» Age etc of plover please?
Sun Nov 19, 2017 6:57 pm by piston 197


Front fork leg sticking

View previous topic View next topic Go down

Front fork leg sticking

Post  Simon on Tue Aug 15, 2017 9:57 am

My falcon 58 has a sticky front fork leg so before stripping it down is there any probable cause for this or remedies as looking at older posts these forks are difficult to rebuild?
Simon.
avatar
Simon

Posts : 8
Join date : 2017-06-29
Location : East London

Back to top Go down

sticking fork leg

Post  piston 197 on Tue Aug 15, 2017 10:47 am

No simple to rebuild, but if a fork leg is sticking there will either be a dent in the bottom slider, or a bent leg, only way to tell is to take it apart
JH
avatar
piston 197
Moderator

Posts : 3625
Join date : 2008-08-17
Location : ross-on-wye

Back to top Go down

Re: Front fork leg sticking

Post  Simon on Tue Aug 15, 2017 11:35 am

piston 197 wrote:No simple to rebuild, but if a fork leg is sticking there will either be a dent in the bottom slider, or a bent leg, only way to tell is to take it apart
JH



Many thanks for reply JH, good to know there simple to do I shall strip them down then.
avatar
Simon

Posts : 8
Join date : 2017-06-29
Location : East London

Back to top Go down

Fork leg

Post  kerabo on Tue Aug 15, 2017 4:58 pm

If it has damage then you have to take to bits but just a though. Mine were a bit noisy so I filled them to the very top with oil and left it overnight to get into the top bush and then drained and filled with the correct amount and the noise was gone.

Ken
avatar
kerabo

Posts : 2124
Join date : 2008-02-11
Age : 67
Location : Falcon 87. Trials 93 Special. Powerbike 56. Falcon 81 Green Lane bitsa. Sunbeam S8. Honda Deuville.

Back to top Go down

Different forks

Post  piston 197 on Tue Aug 15, 2017 6:20 pm

Ken, the Falcon 58 is a very different fork to your forks, they contain no oil , are not damped and are just oiled through the oil nipples ( oil NOT grease) with an oil gun every 500 miles, they do not need or benefit being filled with oil and unless the top yoke is removed completely before putting in the oil will only fill the inner sliders up and not get to the bushes at all.
The bushes in these forks are tufnol and have a certain amount of inherent lubrication, unlike the bronze/brass bushes in the forks used from the falcon 70 onwards
JH
avatar
piston 197
Moderator

Posts : 3625
Join date : 2008-08-17
Location : ross-on-wye

Back to top Go down

Re: Front fork leg sticking

Post  Sponsored content


Sponsored content


Back to top Go down

View previous topic View next topic Back to top

- Similar topics

 
Permissions in this forum:
You cannot reply to topics in this forum